| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2012-10-16
|
| Emphasis |
N: DUSTEXPL
|
| Case Closed |
2013-03-13
|
Related Activity
| Type |
Complaint |
| Activity Nr |
611292 |
| Safety |
Yes |
| Health |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
5A0001 |
| Issuance Date |
2013-01-29 |
| Current Penalty |
952.0 |
| Initial Penalty |
2380.0 |
| Final Order |
2013-03-13 |
| Nr Instances |
1 |
| Nr Exposed |
10 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
Section 5(a)(1) of the Occupational Safety and Health Act of 1970: The employer did not furnish employment and a place of employment that was free from recognized hazards that were causing or likely to cause death or serious physical harm to employees in that employees were exposed to struck by hazards due to missing safety latches on hooks used overhead gantry cranes: a) For the Globe Trailers facility at 3101 59th Ave. Drive East, Bradenton, FL 34203, as observed on or about 10/16/2012, hooks and chains were used with overhead gantry cranes to lift newly fabricated trailers. Safety latches were broken and/or missing on hooks used to make to lifts. The trailers weighed over a thousand pounds. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19100107 L04 I |
| Issuance Date |
2013-01-29 |
| Current Penalty |
200.0 |
| Initial Penalty |
500.0 |
| Final Order |
2013-03-13 |
| Nr Instances |
1 |
| Nr Exposed |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.107(l)(4)(i): All areas were not kept free of the accumulation of powder coating dust: a) For the Globe Trailers facility at 3101 59th Ave. Drive East, Bradenton, FL 34203, as observed on or about 10/16/2012, combustible powder coating dust had accumulated in the powder coating equipment and storage room, next to the powder coating booth, at levels of 1/32 inch or greater. The dust had settled on the entire floor surface area and on equipment and storage racks. The powder coating dust was analyzed to be a class II dust with an explosion severity of 0.6900, and presented a fire hazard in the storage room. |
|
| Citation ID |
01003 |
| Citaton Type |
Serious |
| Standard Cited |
19100242 B |
| Issuance Date |
2013-01-29 |
| Current Penalty |
952.0 |
| Initial Penalty |
2380.0 |
| Final Order |
2013-03-13 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.242(b): Compressed air used for cleaning purposes was not reduced to less than 30 p.s.i.: a) For the Globe Trailers facility at 3101 59th Ave. Drive East, Bradenton, FL 34203, as observed on or about 10/16/2012, employees used compressed air at pressures of 70 p.s.i. dead front pressure to clean off parts/shavings. |
|
| Citation ID |
01004 |
| Citaton Type |
Serious |
| Standard Cited |
19100306 B01 I |
| Issuance Date |
2013-01-29 |
| Current Penalty |
1190.0 |
| Initial Penalty |
2975.0 |
| Final Order |
2013-03-13 |
| Nr Instances |
1 |
| Nr Exposed |
10 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.306(b)(1)(i): Readily accessible disconnecting means were not provided between the runway contact conductors and the power supply on cranes or hoists:(a)(LOCATION)(IDENTIFY EQUIPMENT AND CONDITION(S))(STATE HAZARD(S) TO EMPLOYEE(S)) a) For the Globe Trailers facility at 3101 59th Ave. Drive East, Bradenton, FL 34203, as observed on or about 10/16/2012, electrical control pendants used to operate 3 and 5 ton hoists had their emergency stop buttons broken off. |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19100107 B05 I |
| Issuance Date |
2013-01-29 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-13 |
| Nr Instances |
1 |
| Nr Exposed |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.107(b)(5)(i): Visible gauges or audible alarm or pressure activated devices were not installed to indicate or insure that the required air velocity was maintained: a) For the Globe Trailers facility at 3101 59th Ave. Drive East, Bradenton, FL 34203, as observed on or about 10/16/2012, no manometer or any other equivalent device was functioning to indicate if and when the filters were clogged for the powder coating booth. |
|
| Citation ID |
02002 |
| Citaton Type |
Other |
| Standard Cited |
19100134 C01 |
| Issuance Date |
2013-01-29 |
| Abatement Due Date |
2013-02-15 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-13 |
| Nr Instances |
1 |
| Nr Exposed |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(c)(1): A written respiratory protection program that included the provisions in 29 CFR 1910.134(c)(1)(i) - (ix) with worksite specific procedures was not established and implemented for required respirator use: a) For the Globe Trailers facility at 3101 59th Ave. Drive East, Bradenton, FL 34203, as observed on or about 10/16/2012, employees used N-95 filtering face piece respirators, half face cartridge respirators, and supplied air hoods/respirators. Respiratory protection was required in areas, and a written respiratory protection program was not present at the facility. |
|
| Citation ID |
02003 |
| Citaton Type |
Other |
| Standard Cited |
19100134 I01 II |
| Issuance Date |
2013-01-29 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-03-13 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1910.134(i)(1)(ii): Breathing air did not meet requirements for Grade D breathing air as described in the ANSI/Compressed Gas Association Commodity Specification G-7.1-1989: a) For the Globe Trailers facility at 3101 59th Ave. Drive East, Bradenton, FL 34203, as observed on or about 10/16/2012, air line manifolds located downstream of supplied breathing air filters were not made by the same manufacturer as the air hose lines and fitttings, and air line connection fittings were observed to be leaking. |
|
|
