| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2018-09-07
|
| Emphasis |
L: FORKLIFT, L: FALL, P: FALL
|
| Case Closed |
2022-10-31
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1371926 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001A |
| Citaton Type |
Serious |
| Standard Cited |
19260100 A |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-06 |
| Current Penalty |
2439.0 |
| Initial Penalty |
4878.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
2 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.100(a): Employees working in areas where there was a possible danger of head injury from impact, or falling or flying objects, or from electrical shock and burns, were not protected by protective helmets: a. On or about 09/06/2018, at the job site, employees were not provided hard hats while roofing material was being thrown from the roof of a 3 story building into trash container that was being lifted by an aerial lift. The employees on the ground were picking up debris & trash directly under the area where the old roofing materials were being thrown into the container. b. On or about 09/07/2018, at the job site, employees were not provided hard hats while roofing material was being thrown from the roof of a 3 story building into trash container that was being lifted by an aerial lift. The employees on the ground were picking up debris & trash directly under the area where the old roofing materials were being thrown into the container. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19260451 G03 IV |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-06 |
| Current Penalty |
2845.5 |
| Initial Penalty |
5691.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.451(g)(3)(iv): Vertical lifelines, independent support lines, and suspension ropes were attached to the same point on the scaffold or personal fall arrest system: a. On or about 09/06/18, on the roof of building 4575, employees attached two lifelines to a single temper roof anchor. |
|
| Citation ID |
01003A |
| Citaton Type |
Serious |
| Standard Cited |
19260453 B02 V |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-06 |
| Current Penalty |
2845.5 |
| Initial Penalty |
5691.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.453(b)(2)(v): A body belt was not worn and/or a lanyard was not attached to the boom or basket when working from an aerial lift: a. On or about 09/06/2018, at the jobsite, the operator of JLG aerial lift was not wearing a safety harness or body belt while operating the lift. |
|
| Citation ID |
01003B |
| Citaton Type |
Serious |
| Standard Cited |
19260454 A |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-10 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
2 |
| Nr Exposed |
14 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.454(a): The employer did not have each employee who performed work while on a scaffold trained by a person qualified in the subject matter to recognize the hazards associated with the type of scaffold being used and to understand the procedures to control or minimize those hazards. a. On or about 09/06/2018, at the jobsite, untrained employees were allowed to operate a JLG aerial lift. b. On or about 09/07/2018, at the jobsite, untrained employees were allowed to operate a JLG aerial lift. |
|
| Citation ID |
01003C |
| Citaton Type |
Serious |
| Standard Cited |
19260502 D16 III |
| Issuance Date |
2018-11-28 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.502(d)(16)(iii): Personal fall arrest systems, when stopping a fall, were not rigged such that an employee could not free fall more than 6 feet (1.8 m) nor contact any lower level: a. On or about 9/7/2018, at the jobsite, an employee operating an aerial lift used rope as safety lanyard for his personal fall arrest system and the rope was rigged where the employee could fall more than 6 feet. |
|
| Citation ID |
01004A |
| Citaton Type |
Serious |
| Standard Cited |
19260502 D15 |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-06 |
| Current Penalty |
2032.5 |
| Initial Penalty |
4065.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
14 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.502(d)(15): Anchorage points used for attachment of personal fall arrest equipment were not independent of any anchorage point being used to support or suspend platforms and capable of supporting at least 5,000 pounds (22.2 kN) per employee: a. On or about 09/06/2018, at the jobsite, the Guardian temper roof anchors being used by employees doing roofing work were not installed per the manufacture's recommendation, in that, the required number of fasteners (12) were not used. |
|
| Citation ID |
01004B |
| Citaton Type |
Serious |
| Standard Cited |
19260503 A02 |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-10 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
2 |
| Nr Exposed |
14 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.503(a)(2): The employer did not assure that each employee exposed to fall hazards was trained by a competent person qualified in the areas specified in 29 CFR 1926.503 (a)(2)(i) through (viii): a. On or about 09/06/2018, at the jobsite, employees working on a 5:12 pitched roof were not trained on fall protection and the employees were exposed to a 30 foot fall hazard. b. On or about 09/07/2018, at the jobsite, employees working on a 5:12 pitched roof were not trained on fall protection and the employees were exposed to a 30 foot fall hazard. |
|
| Citation ID |
01005A |
| Citaton Type |
Serious |
| Standard Cited |
19261053 B01 |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-06 |
| Current Penalty |
2845.5 |
| Initial Penalty |
5691.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
14 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1053(b)(1): Where portable ladders were used for access to an upper landing surface and the ladder's length allows, the ladder side rails did not extend at least 3 feet (.9 m) above the upper landing surface being accessed: a. On or about 08/21/2018, at the job site - the rails of the ladder used to access the roof of the building did not extend at least 3 foot above the upper landing surface, exposing the employees to about an 10 foot fall hazard. |
|
| Citation ID |
01005B |
| Citaton Type |
Serious |
| Standard Cited |
19261060 A01 |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-10 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
14 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1060(a)(1): The employer did not provide a training program for each employee using ladders as necessary, enabling each employee to recognize hazards related to ladders and the procedures to be followed to minimize these hazards. a. On or about 08/21/2018, at the job site - employees required to use a ladder to access the roof of the building were not provided with training. The employees were exposed to about a 10 foot fall hazard. |
|
| Citation ID |
02001 |
| Citaton Type |
Willful |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-06 |
| Current Penalty |
28454.0 |
| Initial Penalty |
56908.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
14 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee engaged in residential construction activities 6 feet (1.8 m) or more above lower levels was not protected by guardrail systems, safety net systems, personal fall arrest systems, or an alternative fall protection measure under another provision of paragraph 1926.501 (b): a. On or about 09/06/2018, at the jobsite, employees doing residential roofing work on a 5:12 pitch roof were not protected from falling approximately 30 feet to the ground below. OCEAN ROOFING OF FLORIDA LLC WAS PREVIOUSLY CITED FOR A VIOLATION OF THIS OCCUPATIONAL SAFETY AND HEALTH STANDARD OR ITS EQUIVALENT STANDARD 29 CFR 1926.501(B)(13), WHICH WAS CONTAINED IN OSHA INSPECTION NUMBER 1114746, CITATION NUMBER 01, ITEM NUMBER 001 AND WAS AFFIRMED AS A FINAL ORDER ON 06/13/2016, WITH RESPECT TO A WORKPLACE LOCATED AT 3140 57TH AVE CIRCLE EAST, BRADENTON, FL 34203. |
|
| Citation ID |
03001 |
| Citaton Type |
Other |
| Standard Cited |
19260502 D21 |
| Issuance Date |
2018-11-28 |
| Abatement Due Date |
2018-12-06 |
| Current Penalty |
228.0 |
| Initial Penalty |
456.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
14 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.502(d)(21): Personal fall arrest systems were not inspected prior to each use for wear, damage, and other deterioration, and/or defective components were not removed from service: a. On or about 09/06/2018, at the jobsite, the fall protection equipment provided to employees was not inspected prior to the equipment being installed and used on a 5:12 pitch roof. |
|
|
| Inspection Type |
Complaint
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2018-08-21
|
| Emphasis |
L: FALL
|
| Case Closed |
2023-02-07
|
Related Activity
| Type |
Complaint |
| Activity Nr |
1371926 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Repeat |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2018-11-13 |
| Current Penalty |
3880.0 |
| Initial Penalty |
7760.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
9 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system, nor were employee(s) provided with an alternative fall protection measure under another provision of paragraph 1926.501 (b): a. On or about 08/21/2018, at the job site - employees working from 5:12 roof were exposed to 34 feet fall hazards while conducting roofing work, in that, fall protection was not used. OCEAN ROOFING OF FLORIDA LLC WAS PREVIOUSLY CITED FOR A VIOLATION OF THIS OCCUPATIONAL SAFETY AND HEALTH STANDARD OR ITS EQUIVALENT STANDARD 29 CFR 1926.501(B)(13), WHICH WAS CONTAINED IN OSHA INSPECTION NUMBER 1114746, CITATION NUMBER 01, ITEM NUMBER 001 AND WAS AFFIRMED AS A FINAL ORDER ON 06/13/2016, WITH RESPECT TO A WORKPLACE LOCATED AT 3140 57TH AVE CIRCLE EAST, BRADENTON, FL 34203. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19261053 B01 |
| Issuance Date |
2018-11-13 |
| Abatement Due Date |
2018-11-26 |
| Current Penalty |
1940.0 |
| Initial Penalty |
3880.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
6 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1053(b)(1): Where portable ladders were used for access to an upper landing surface and the ladder's length allows, the ladder side rails did not extend at least 3 feet (.9 m) above the upper landing surface being accessed: a. On or about 08/21/2018, at the job site - the rails of the ladder used to access the second floor of the building did not extend at least 3 foot above the upper landing surface, exposing the employees to about a 10 feet fall hazard. |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19260503 B01 |
| Issuance Date |
2018-11-13 |
| Abatement Due Date |
2018-11-26 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.503(b)(1): The employer did not verify compliance with paragraph (a) of this section by preparing a written (training) certification record including the name or other identity of the employee trained, the date(s) of the training, and the signature of the person who conducted the training or the signature of the employer. a. On or about 08/21/2018, at the job site - employees conducting roofing work were exposed to a 34 feet fall hazards, and the employer did not provided written certification of fall protection training. |
|
| Citation ID |
02002 |
| Citaton Type |
Other |
| Standard Cited |
19261060 A01 |
| Issuance Date |
2018-11-13 |
| Abatement Due Date |
2018-11-26 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2019-01-16 |
| Nr Instances |
1 |
| Nr Exposed |
6 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1060(a)(1): The employer did not provide a training program for each employee using ladders as necessary, enabling each employee to recognize hazards related to ladders and the procedures to be followed to minimize these hazards. a. On or about 08/21/2018, at the job site - employees required to use a ladder to access the roof of the building were not provided with training. The employees were exposed to about a 10 feet fall hazard. |
|
|
