|
340650076
|
0419700
|
2015-05-19
|
6101 EDITH STEPHENS DRIVE, PANAMA CITY, FL, 32405
|
|
| Inspection Type |
Planned
|
| Scope |
Complete
|
| Safety/Health |
Safety
|
| Close Conference |
2015-05-20
|
| Emphasis |
L: FALL, P: FALL
|
| Case Closed |
2020-08-19
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19261051 A |
| Issuance Date |
2015-09-14 |
| Current Penalty |
5390.0 |
| Initial Penalty |
5390.0 |
| Final Order |
2015-10-08 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1051(a): Stairway(s) or ladder(s) were not provided at all personnel points of access where there was a break in elevation of 19 inches (48 cm) or more, or no ramp, runway, sloped embankment, or personnel hoist was provided: a. On or about May 19, 2015, the employees climbed the walls and bracing to access and exit from the upper surface because there were no ladders at the job site. Employees was being exposed to fall hazards up to 10.5 feet high. |
|
| Citation ID |
02001 |
| Citaton Type |
Willful |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2015-09-14 |
| Current Penalty |
53900.0 |
| Initial Penalty |
53900.0 |
| Final Order |
2015-10-08 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system, nor were employee(s) provided with an alternative fall protection measure under another provision of paragraph 1926.501(b): a. Employees performing residential framing work at elevations of six feet or more above the ground are not protected from fall hazards by a fall protection system. The employer fails to assure effective protection against falls as required by the standard, as demonstrated on May 19, 2015, when employees were setting trusses at a residential house located at 6101 Edith Stephens Drive, Panama City, Florida 32405, without fall protections and were exposed to fall hazards of 8.5 feet above lower level. Panama City Framing & Siding, LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 29 CFR 1926.501(b)(13) which was contained in OSHA inspection number 943691, citation number 01, item number 002, issued on October 30, 2013, with respect to a workplace at 21109 Front Beach Road, Panama City Beach, FL 32401. The final order for this citation was February 5, 2014. Panama City Framing & Siding, LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 29 CFR 1926.501(b)(13) which was contained in OSHA inspection number 915761, citation number 01, item number 002, issued on July 1, 2013, with respect to a workplace at 103 Turtle Cove, Lot 63, Panama City Beach, FL 32407. The final order date for this citation was August 9, 2013. Panama City Framing & Siding, LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 29 CFR 1926.501(b)(11) which was contained in OSHA inspection number 696998, citation number 01, item number 002, issued on October 20, 2012, with respect to a workplace at 12905 Panama City Beach Parkway, Panama City Beach, FL 32413. The final order for this citation was December 14, 2012. |
|
| Citation ID |
03001 |
| Citaton Type |
Repeat |
| Standard Cited |
19260100 A |
| Issuance Date |
2015-09-14 |
| Current Penalty |
6160.0 |
| Initial Penalty |
6160.0 |
| Final Order |
2015-10-08 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.100(a): Employees working in areas where there is a possible danger of head injury from impact, or from falling or flying objects, or from electrical shock and burns, shall be protected by protective helmets: a. On or about May 19, 2015, the employee hoisting up trusses to other employees did not have on a hard hat, exposing himself to head injuries. Panama City Framing & Siding, LLC, was previously cited for a violation of this occupational safety and health standard or it's equivalent standard 29 CFR 1926.100(a) which was contained in OSHA inspection number 915761, citation number 2, item number 1, issued on July 18, 2013, with respect to a workplace at 103 Turtle Cove, Lot 63, Panama City Beach, FL 32407. The final order for this citation was August 9, 2013. |
|
| Citation ID |
03002 |
| Citaton Type |
Repeat |
| Standard Cited |
19260102 A01 |
| Issuance Date |
2015-09-14 |
| Current Penalty |
6160.0 |
| Initial Penalty |
6160.0 |
| Final Order |
2015-10-08 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.102(a)(1): Eye and face protective equipment were not used when machines or operations presented potential eye or face injury from physical, chemical, or radiation agents: a. On or about May 19, 2015, employees using nail guns and saws were not wearing safety glasses, exposing themselves to eye injuries. Panama City Framing & Siding, LLC was previously cited for a violation of this occupational safety and health standard or its equivalent standard 29 CFR 1926.102(a)(1) which was contained in OSHA inspection number 943691, citation number 01, item number 001, issued on October 30, 2013, with respect to a workplace at 21109 Front Beach Road, Panama City Beach, FL 32401. The final order for this citation was February 5, 2014. |
|
|
|
339436917
|
0419700
|
2013-10-23
|
21109 FRONT BEACH ROAD, PANAMA CITY BEACH, FL, 32401
|
|
| Inspection Type |
Planned
|
| Scope |
Complete
|
| Safety/Health |
Safety
|
| Close Conference |
2013-10-23
|
| Emphasis |
L: EISAOF, L: FALL, P: FALL
|
| Case Closed |
2020-08-19
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19260102 A01 |
| Issuance Date |
2013-10-30 |
| Current Penalty |
2400.0 |
| Initial Penalty |
2400.0 |
| Final Order |
2014-02-06 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.102(a)(1): Eye and face protective equipment were not used when machines or operations presented potential eye or face injury from physical, chemical, or radiation agents: a. On or about October 23, 2013, two employees using NR83A2 Hitachi air nail guns were not wearing safety glasses, exposing themselves to being hit by nails or flying debris. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2013-10-30 |
| Current Penalty |
2800.0 |
| Initial Penalty |
2800.0 |
| Final Order |
2014-02-06 |
| Nr Instances |
1 |
| Nr Exposed |
5 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system, nor were employee(s) provided with an alternative fall protection measure under another provision of paragraph 1926.501 (b): a. On or about October 23, 2013, on the top of the joist, five employees performing framing operations were not protected from a 12-foot fall hazard by the use of a guardrail system, safety net system, personal fall arrest system or any alternative fall protection. |
|
| Citation ID |
01003 |
| Citaton Type |
Serious |
| Standard Cited |
19261053 B01 |
| Issuance Date |
2013-10-30 |
| Current Penalty |
2000.0 |
| Initial Penalty |
2000.0 |
| Final Order |
2014-02-06 |
| Nr Instances |
1 |
| Nr Exposed |
5 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1053(b)(1): Portable ladders were used for access to an upper landing surface and the ladder side rails did not extend at least 3 feet (.9m) above the upper landing surface to which the ladder was used to gain access: a. On or about October 23, 2013, the Louisville extension ladder used to access and egress the top of a structure, did not extend 3-feet above the eave, exposing employees to a 12-foot fall hazard. |
|
|
|
339157612
|
0419700
|
2013-07-01
|
103 TURTLE COVE LOT 63, PANAMA CITY BEACH, FL, 32407
|
|
| Inspection Type |
Planned
|
| Scope |
Complete
|
| Safety/Health |
Safety
|
| Close Conference |
2013-07-01
|
| Emphasis |
L: FALL, P: FALL
|
| Case Closed |
2020-08-19
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19260451 G01 |
| Issuance Date |
2013-07-18 |
| Abatement Due Date |
2013-08-13 |
| Current Penalty |
2800.0 |
| Initial Penalty |
2800.0 |
| Final Order |
2013-08-12 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Related Event Code (REC) |
Referral |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.451(g)(1): Employees on scaffolds more than 10 feet (3.1 m) above a lower level were not protected from falling to that lower level by fall protection established in paragraphs (g)(1)(i)-(vii) of this section: a. On or about July 1, 2013, on the south side of the house, the ladder jack scaffold did not have a guardrail or other fall protection system, exposing employees to a 14 feet 8 inch fall hazard. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2013-07-18 |
| Current Penalty |
2800.0 |
| Initial Penalty |
2800.0 |
| Final Order |
2013-08-12 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Related Event Code (REC) |
Referral |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system: a. On or about July 1, 2013, on the north side of the house, the 2nd level balcony did not have a guardrail, exposing employees to an 11 feet fall hazard. |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19260100 A |
| Issuance Date |
2013-07-18 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2013-08-12 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Related Event Code (REC) |
Referral |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.100(a): Employees working in areas where there was a possible danger of head injury from impact, or falling or flying objects, or from electrical shock and burns, were not protected by protective helmets: On July 1, 2013, on the north side of the house, employees installing siding material to the sides of a house were not wearing hard hats while working below employees on a 2nd story balcony and on scaffold, exposing employees to the hazard of being struck by falling debris. |
|
|
|
336969985
|
0419700
|
2012-10-20
|
12905 PANAMA CITY BEACH PARKWAY, PANAMA CITY BEACH, FL, 32413
|
|
| Inspection Type |
Planned
|
| Scope |
Complete
|
| Safety/Health |
Safety
|
| Close Conference |
2012-10-20
|
| Emphasis |
L: FALL
|
| Case Closed |
2020-08-19
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19260501 B04 II |
| Issuance Date |
2012-11-06 |
| Current Penalty |
1600.0 |
| Initial Penalty |
1600.0 |
| Final Order |
2012-12-05 |
| Nr Instances |
2 |
| Nr Exposed |
3 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(4)(ii): Each employee on a walking/working surface was not protected from tripping in or stepping into or through holes by covers. a. On or about October 20, 2012, on the interior 2nd floor of the building, employees were working around un-protected holes in the floor, exposing themselves to a trip hazard. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19260501 B11 |
| Issuance Date |
2012-11-06 |
| Current Penalty |
2800.0 |
| Initial Penalty |
2800.0 |
| Final Order |
2012-12-05 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(11): Each employee on a steep roof with unprotected sides and edges 6 feet (1.8 m) or more above lower levels was not protected from falling by guardrail systems with toeboards, safety net systems, or personal fall arrest systems: a. On or about October 20, 2012, employees performing work on a 6:12 pitch roof were not protected from a 20-foot fall hazard by the use of of a fall protection system. b. On or about October 20, 2012, employees performing work on a 5:12 pitch roof were not protected from a 14-foot fall hazard by the use of a fall protection system. |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19260020 B01 |
| Issuance Date |
2012-11-06 |
| Abatement Due Date |
2012-12-26 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2012-12-05 |
| Nr Instances |
1 |
| Nr Exposed |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.20(b)(1): A safety and health program was not initiated and maintained to provide compliance with the general safety and health provisions of the standard: 1. Management Commitment and Leadership A. Policy statement: goals established, issued, and communicated to employees. B. Program Reviewed Annually. C. Participation in safety meetings, inspections; agenda item in meetings. D. Adequate commitment of resources. E. Safety rules and procedures incorporated into site operations. F. Management observations of safety rules. 2. Assignment of Responsibility A. Safety designee on site, knowledgeable, and accountable. B. Supervisors' (including foremen) safety and health responsibilities understood. C. Employees adherence to safety rules. 3. Identification and Control of Hazards A. Periodic site inspection program involving supervisors. B. Preventive controls in place (PPE, Maintenance, Engineering Controls). C. Action taken to address hazards. D. Safety Committee, where appropriate. E. Technical reference materials available. 4. Training and Education A. Supervisors receive basic safety and health training. B. Specialized training taken when needed. C. Existence of an employee training program, which is ongoing and effective. 5. Recordkeeping and Hazard Analysis A. Records maintained of employee illnesses/injuries, and posted. B. Supervisors perform incident investigations, determine causes, propose corrective action. C. Injuries, near misses, and illnesses are evaluated for trends, similar causes; corrective action initiated. 6. First Aid and Medical Assistance A. First aid supplies and medical services available. B. Employees informed of medical results. C. Emergency procedures and training, where necessary. a. On or about October 20, 2012, at the worksite, a safety and health program had not been initiated and maintained which addressed the basic elements. |
|
|
